New | C4.4 Generator Set

Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.

Generator Set Specifications
Height - Maximum53.6 in
Length - Maximum75.8 in
Width - Maximum44.1 in
Minimum Rating36 ekW
Maximum Rating60 ekW
Voltage208-600 Volts
Frequency60 Hz
Speed1800 RPM
Generator Set Configurations
Emissions/Fuel StrategyU.S. EPA Certified for Stationary Emergency Use Only (Tier 3 Nonroad Equivalent Emission Standards)
Engine Specifications
Engine ModelC4.4, In-line 4, 4-cycle diesel
Compression Ratio18.2:1
Governor TypeAdem™A4
Fuel SystemElectronic (adjustable)
Bore4.13 in
Displacement268.5 in
Stroke5 in

  • The Generator Set Is Designed To Meet Iso8528-5 Transient Response And Nfpa 110.
  • Cooling System Designed To Operate In 50˚c / 122˚f Ambient Temperatures With An Air Flow Restriction Of 0.5 In. Water.
  • Fully Prototype Tested With Certified Torsional Vibration Analysis Available

    Ce Certification Available

    Cat Dealers Provide Extensive Post-sale Support Including Maintenance And Repair Agreements. Cat Dealers Have Over 1,800 Dealer Branch Stores Operating In 200 Countries. The Caterpillar S•o•s℠ Program Cost Effectively Detects Internal Engine Component Condition, Even The Presence Of Unwanted Fluids And Combustion By-products

  • single Wall 8 Hour Wide Fuel Tank
  • circuit Breaker, Iec, 3 Pole
  • industrial Silencer (10dba)
  • Standard Equipment

    Charging System
    • CAT Premium High Output Battery(s) with rack & cables Installed (wet);1000CCA;90amp hr;12V
    Control System
    • EMCP 4.2
    • Controls include: Run / Auto / Stop Control - Speed Adjust - Engine Cycle Crank - Emergency Stop pushbutton
    • Features include: 12-volt DC operation - Environmental sealed front face - Text alarm/event descriptions
    • Digital indators for: RPM - DC volts - Operating hours, - Oil pressure - Coolant pressure - Volts (L-L & L-N), frequency (Hz) - Amps (per phase & average) - Power Factor (per phase & average) - kW (per phase,average & percent) - kVA (per phase,average & percent) - kVAr (per phase,average & percent) - kW-hr (total) - kVAr-hr (total)
    • Warning / Shutdown with common LED indicators for: -Low Oil pressure - Low coolant temperature alarm (detects jkt water heater failure) - High coolant temperature shutdown
    • Communications: Customer DATA link (Modbus RTU) - RS485 Serial DATA link (terminals only) - 8 programmable digital outputs available - 2 relays pre-programmed - 8 programmable digital inputs available - 2 pre-programmed
    Circuit Breakers
    • Optional UL/CSA listed mainline breakers
    • Optional Multiple Breakers 100% Rated 3-pole with solid neutral
    • NEMA 1 steel enclosure
    • Electrical stub-up area directly below circuit breaker
    Cooling System
    • Radiator and cooling fan complete with protective guards
    • Standard ambient temperatues up to 50degC (122degF)
    • 50% coolant antifreeze/corrosion inhibitor
    • Coolant reservoir
    Generator
    • Insulation system,class H
    • Drip proof generator air intake (NEMA 2,IP23)
    • Electrical design in accordance with BS5000 Part 99,EN61000-6, IEC60034-1,NEMA MG-1.33
    • All electroplated hardware or stainless steel
    • Anticorrosive paint protection
    • High gloss polyurethane paint for durability and scuff resistance
    Mounting System
    • Heavy-duty fabricated steel base with lifting points
    • Anti-vibration pads to ensure vibration isolaton
    • Complete OSHA guarding
    • Stub-up pipe ready for connection to silencer pipework
    • Flexible fuel lines to base with NPT connections
    General
    • Warranty per SELF5611

    Optional Equipment

    Certificates
    • IBC Seismic and Wind Certifications
    Air Inlet System
    • Cartridge type air filter
    Charging System
    • NFPA battery charger UL10A 120VAC
    Circuit Breakers
    • 3-Pole 100% rated
    • Breakers (100% UL rated)
    • Second circuit breaker box
    • Power perminal strips
    Control Panels
    • NFPA110 bundle includes: FSS low fuel level alarm & indication panel circuitry required when sub-base tank is selected - WSS1 Low Coolant level shut down - WCA1 Low Coolant temperature alarm - PAA1 Panel mounted audible alarm - PBC10NU NFPA Battery Charger - A coolant heater ,remote annunciator or 0.8 power factor test may be required depending on the application
    • Oil temperature guage and sender
    • Audible alarm
    • Ground fault relay
    • Discrete I/O module
    • Remote E-stop button
    • Volt free contacts genset run and common alarm
    • Remote annunciator
    • Protective devices: Low coolant temperature alarm - Low coolant level shutdown - Fuel level reading - Overload shutdown via breaker
    Cooling System
    • Radiator stone guard
    • Radiator transition flange
    Enclosures
    • Weatherproof enclosure
    • Sound attenuated enclosure, level 1
    • Sound attenuated enclosure, level 2
    • Panel viewing window
    • External emergency stop
    Heating Elements
    • Coolant heater
    • Jacket water heater
    • Anti-condensation heater
    • Battery heater
    • Lube oil sump heater
    • Wiring for canopy space heater
    Exhaust System
    • 10, 25 and 35 dBA silencer systems
    • Overhaed silencer mounting kit
    Fuel System
    • 209 and 394 gallon sub-base fuel tanks
    • 5 gallon fill containment
    • 5 gallon spill containment
    • Emergency vent pipe
    • Tank riser
    Generators
    • Permanent magnet generator
    Mounting System
    • Seismic vibration isolators
    Tests
    • Generator test report
    • PGS test report @ 1.0 power factor
    • PGS test report @ 0.8 power factor
    • 4 Hour factory test

    listofrelationships

    original

    original

    Other Models in this Category

    Select Generator Type


    Hawthorne Power Systems Logo

    Request a Quote

    Why Cat is Better. Machine Comparison

    "
    With only a few days notice, we were able to get the emergency system working properly. Hawthorne Cat provided great leadership and excellent field support.
    Mark Cripe
    Helix Electric
    "

    San Diego - Power
    Phillip J. Smith (PJ)
    Field Service Manager
    858.376.6874 office
    858.688.0134 mobile
    psmith@hawthornecat.com

    Paul Karpf
    Rental Department Manager
    858.376.6888 office
    858.688.0039 mobile
    pkarpf@hawthornecat.com

    Tom Bonham
    Product Support Sales Manager
    858.376.6898 office
    442.248.2108 mobile
    tbonham@hawthornecat.com

    Hawaii – Power
    Cliff Yuen
    Power Systems Sales Manager
    808.676.0322 office
    808.349.7767 mobile
    cyuen@hawthornecat.com

    Guam – Power
    Myver Hecita
    Power Systems Rental &
    Sales Representative
    671.649.4241 office
    671.898.2740 mobile
    mhecita@hawthornecat.com

    Richard Nostratis
    Service Manager
    671.649.4212 office
    671.898.2735 mobile
    rnostratis@hawthornecat.com