Air Inlet System- Air cleaner; single element canister type
|
Cooling |
Exhaust |
Fuel- Primary fuel filter with integral water separator
- Secondary fuel filter
|
Generator- Matched to the performance and output characteristics of Cat engines
- IP23 Protection
|
Power Termination |
Control Panels- Engine cool-down timer
- Frequency (Hz)
- DC Volts
- Volts (L-L & L-N)
- Customizable screens
- Limiter and exciter diode monitor
- Power Factor (per phase & average)
- 1 Programmable relay outputs (Form C
- Text alarm/event descriptions
- Speed adjust
- 1 Programmable digital outputs
- Overspeed - Emergency stop
- 4 Programmable relay outputs (Form A)
- Emergency stop - Failure to start (overcrank)
- Reverse reactive power (kVAr) (32RV)
- 6 Customer programmable digital inputs
- Customer data link (Modbus RTU)
- Emergency stop pushbutton
- Environmental sealed front face
- kW-hr (total) - kVAr-hr (total)
- Cat Connect
- Load histogram feature
- RPM - DC volts
- Failure to start (overcrank)
- Serial annunciator module data link
- Coolant temperature
- Operating hours
- kW (per phase, average & percent)
- IVR includes:
- Low coolant temperature
- Reactive droop capability
- Generator set packages include Caterpillar' s Voltage
Regulator
- Digital indication for:
- KVAR/PF modes
- Lamp test
- Controls:
- PLC functionality
- 0 True RMS AC metering, 3-phase, +/-2% accuracy
- Oil pressure (psi, kPa or bar)
- Generator mounted - rear facing
- Amps (per phase & average)
- Low coolant level
- 3 Analog inputs
- Reverse power (kW) (32)
- 24 Volt DC operation
- Over / under voltage (2 7/ 59)
- Over / under frequency (81 o/u)
- RFI suppression
- 3 Phase voltage sensing
- EMCP 4.2B
- Alarm acknowledge
- Auto/start/stop control
- kVA (per phase, average & percent)
- Min / max exciter
- Engine cycle crank
- Low oil pressure
- Accessory module data link
- High coolant temperature
- Warning / shutdown with common LED indication of shutdowns for:
- Communications:
- Overcurrent (50 / 51)
- Number of I/O varies on options selected:
- Programmable protective relaying functions:
|
Control Panel |
Cooling System- Certified standard PGS provided
- ATAAC - 3516E Package Radiators shipped installed
|
Exhaust System- Dry exhaust manifold
- Flanged faced outlet(s)
|
Fuel System- Secondary fuel filters
- Flexible fuel lines - shipped loose
- Fuel cooler; not included with packages without radiator
- Fuel priming pump
|
General- Paint - Caterpillar Yellow except rails and radiators gloss black
- Right hand servicing
- Flywheel and flywheel housing - SAE No. 00
- SAE Standard rotation
- Caterpillar yellow with high gloss black rails and radiator
|
Generator and Attachments- Busbar connections, right side extension box, bottom cable entry
- 3 Phase brushless, salient pole
- Form wound - Permanent magnet
- Anti condensation Space Heater
- Busbar connections, top center mounted, top cable entry
- 6 Leads
- Winding temperature detectors
- Class H temperature rise at 40C ambient (125C prime / 150C standby)
- Form wound
- Internal excitation
- NEMA Class H insulation
- Low Voltage:
- Random wound
- High voltage:
- Medium voltage:
- Class H insulation, Class F temperature rise at 40C ambient (105C prime / 130C standby)
- NEMA Class H insulation, Class H temperature rise at 40C ambient (125C prime / 150C standby
- Permanent magnet
- NEMA standard hole pattern
|
Governing System |
Literature |
Lubrication System- Fumes disposal
- Oil drain lines and valve
- Lubricating oil
- Integral lube oil cool
- Oil filter, filler and dipstick
- Gear type lube oil pump
|
Mounting System- Rails - engine / generator / radiator mounting
- Anti-vibration mounts (shipped loose)
- Rubber anti-vibration mounts (shipped loose)
|
Starting System- Battery and battery rack w/cables
- 24 Volt electric starting motor
- Battery disconnect switch
- 45 Amp charging alternator
|
Control System |
Exhaust |
Air Inlet System- Single element filter
- Dual element air cleaner
|
Generator- Oversize and premium generators
- Permanent magnet excitation (PMG)
- Anti-condensation heater
- Internal excitation (IE)
|
Cooling System- Standard ambient radiators
- Coolant
- Optional installed radiators
- Optional installed ATAAC radiators
- Standard ambient ATAAC radiators
- Water level switch gauges
|
Power Termination- Circuit breakers, IEC compliant
- Circuit breakers, UL listed
|
Crankcase System- Ventilation system
- Explosion relief valves
- No explosion relief valves
|
Control Panels- Remote monitoring software
- Load share module
- Digital I/ O module
- Generator temperature monitoring & protection
|
Exhaust System- Y-Adapters
- Elbows
- Mufflers
- Flange and exhaust expanders
- Clean emission parts
- Tier 4 dosing cabinet
- Exhaust offset
- Flexible fittings
- Tier 4 clean emission MOD Kits
- Flanges
- Tier 4 clean emissions module
|
Fuel System- Primary fuel filter
- Fuel Priming Pumps (Tier 4) - Manual or electric
|
Starting/Charging- Air starting motor with control and silencer
- Charging alternator
- Oversize batteries
- Heavy-duty starting system
|
Generators and Attachments- Differential current transformers (DCT)
- Thermostate for space heater
- Differntial current transformers (DCT) 8.7 kV and 15 kV classes
- Alternator air cleaner
- Generator conversion
- Space heater
- Low / Medium voltage: 380/400/415 volts, 3 phase 1500 rpm. RW, IE, No. of Leads = 6, Pitch = .6667: 1600 Frame
- Low / Medium voltage: 380/400/415 volts, 3 phase 1500 rpm. RW, PM, No. of Leads = 6, Pitch = .6667: 1600 and 1800 Frames
|
Instrumentation- Pyrometer and thermocouples
|
General- Special paint (Colors other than Caterpillar yellow or high performance paints)
- US aid emblem
- EEC Declaration of Conformity
- Automatic transfer switches (ATS)
- CSA Certification
- Seismic Certification per applicable building codes: IBC 2000, IBC 2003, IBC 2006, IBC 2009, CBC 2007
- Enclosures: sound attenuated, weather protective
- The following options are based on regional and product configuration:
- Integral & sub-base fuel tanks
- EU Certificate of Conformance (CE)
- Integral & sub-base UL listed dual wall fuel tanks
- UL 2200 package
|
Lubrication System- Lube oil in standard sump
- Oil level regulator
- Prelube pumps
|
Mounting System- IBC vibration isolators
- Spring type vibration isolators
- Puck style low efficiency isolators
|
Mounting |
Power Connections- Neutral ground connections
- Center post busbar
- Low voltage circuit breakers
- 2700 Frame, four lead, four terminal
- Right side power connections
- Ground cables between generator and terminal box
- Rear power connections
- Left side power connections
|
Special Tests / Reports- Standard engine test charge
- Torsional vibration analysis reports
- PGS test report @ 1.0 power factor
- Fuel consumption test
- IBC certification
- Canadian Standards Association certification
- PGS test report @ 0.8 power factor
- generator test report
- Generator set fuel consumption test
- OSHPD certification
|
Starting and Charging- Air starting motors
- Jacket water heaters
- Starter cover
- 10, 20, 35 and 50 amp battery chargers
- Air pressure regulator
- Electric starting motors
- Engine barring device
- 24 Volt battery set - Dry
|
Extended Service Coverage- Platinum, Gold and Silver coverage
|